The blog has been quiet the past couple of days because we’ve been deep into the Alumapalooza pre-event routine. We’ve settled into a pattern for the set-up of these events, which started before we arrived. This year we have a slightly larger staff than before, and they are all really excellent, so the workload for us has gotten much lighter. When we pulled in to Airstream’s Terra Port on Saturday, everything was so well under control that there was little to do but get updated, and on Sunday instead of joining the goody-bag assembly line, I was able to spend the day with Super Terry doing some maintenance to our Airstream.
The maintenance was primarily about inspecting our tires and wheel bearings. It has been over three years since the bearings were re-packed, and many miles, which is far beyond the usual RV industry recommendation. Paradoxically, our heavy and regular use of the trailer is one of the reasons we’ve gotten away with it. Sitting still isn’t great for the bearings, as it offers an opportunity for condensation to get in. I’ve also periodically checked the bearings to ensure they are running cool, and whenever a wheel is up in the air I check for smoothness & quietness of rotation.
Still, it has been nearly two years and probably over 12,000 miles since the last time Super Terry and I took the wheels off to check things out, so it was definitely overdue. We found that the Michelin tires are still doing well, but wearing more on the outer edge of the tire tread, so we took them over to the Wal-Mart Super Center in a nearby town to get them flipped.
Now the white-letter side of each tire is facing out, and the tires have been swapped from side to side so that they will have the same direction of rotation. This should even out the wear a little. Based on the wear I saw, I’d guess we could get about 50k miles out of them. They’ve already gone over 30,000 miles, and the date code says they are five years old so they are probably going to “age out” before they wear out.
Our inspection revealed that the brake pads were fine except on one wheel, where the disc caliper sliders had gotten dry. When that happens, only one brake pad gets all the wear, so we replaced that set of brake pads and re-lubricated the caliper sliders. Otherwise all was good. Super Terry re-packed the wheel bearings, and re-applied gray Parbond (a sort of thin caulk used for small seams on the exterior) to a few spots that needed it, and that completed our day of maintenance.
Over the weekend I had a few minutes to look around Jackson Center to see what has changed. We knew that the Cafe Veranda, the best restaurant in town, had closed. The building is still for sale. I hope someone buys it and turns it back into a B&B. It’s a gorgeous house and has some interesting history. I’ve heard that Wally Byam used to stay there many decades ago.
The one-screen downtown movie house, the Elder Theatre, is in danger of closing for the same reason as many other old independent screens across the country. The mandatory change to digital projection is too expensive for this little Mom & Pop operation, and so they’ve launched a Kickstarter effort to raise $25,000 to save the theater. Check it out and pledge if you love the little village of Jackson Center, OH. This country is going to lose hundreds of little downtown theaters if they can’t make the digital conversion this year.
Phil’s Cardinal Market, the old grocery store, has been replaced by a spankin’ new Family Dollar store. It’s nice to see some investment in the downtown. It just opened last week and seems very fine. This week the Alumapalooza-goers will flood it and probably clear it out of milk and bread, as they usually do.
On Monday the big deal of the day was the arrival of the tent. Normally the tent crew arrives in the late morning and has it up by 2 or 3 in the afternoon, but this year things ran late, so we didn’t have a chance to get in there and set up our stuff (lights, sound, kitchen, Internet, refrigerators, etc) until after 6 p.m. This was an inconvenience but really not much more than that, so overall I would say setup went extremely well this year.
All weekend we’ve had early arrivals showing up and parking in the Service Center parking lot. At this point I think we have about 25 Airstreams there, plus another ten or so staff trailers in the Terra Port, and probably 6-10 more service customers. Everyone gathered on the grass for the Memorial Day cookout, which was a huge success. The rain we had gotten in the morning cleared up for the afternoon and early evening. It rained again last night and there is still the occasional patter on the roof as I type this (at 6 a.m. Tuesday) but the forecast is calling for improving conditions all day and fabulous conditions through Friday. Only a little rain and not too much heat is a pretty good week in JC this time of year.
Yesterday Dave Schumann showed up and took a few of us into his office to show off a new Airstream guitar. So far only two have been made, but Airstream will get more and sell you one for $2,250 if you are interested. One of our attendees is going to play this one on stage this week.
All week Eleanor and I have been practicing for the new Aluminum Gong Show, which is a featured part of Alumapalooza this week. We’ve got a little routine which involves both of us and a ukulele. If the performance is not great, at least it will be entertaining. I am hoping a few more people sign up to be in the show. Any act is welcome, even pet tricks. It just has to be a minimum of 90 seconds long and a maximum of four minutes. If you are attending Alumapalooza you really don’t want to miss this show, trust me …
It’s time to get moving now. This is going to be one of those days where we do more before 9 a.m. than most people do all day. By 8 we will have a caravan of staff trailers heading out to the field, and by 9 parking of the general attendees will begin. Alumapalooza begins now!